HomeMy WebLinkAboutmemo3
ITEM #2
WINTER SInRTS
SHIRT - WINTER/LONG SLEEVE:
SCOPE - The shirt shall be made in accordance with the following or comparable details unless otherwise
indicated.
MATERIAL - Cloth shall be light grey 8-8-1/2 oz., 55% Dacron and 45% Wool Tropical Worsted. All cloth
must be thoroughly cold water shrunk by the vendor before being used in any gannent. Shall be Hamberger Co.,
Style 600 - 8 or approval equal.
Cloth shall meet the following specifications:
60 inch wide cloth
Weight
Construction
Fiber Content
Wool Grade
Yam Count
8...8-1/2 ounce
60 ends per inch - 50 picks per inch
55% Dacron 45% Wool
Blend of 62-64
Not less than 2150's Dacron & Wool warp and filling.
COLLAR - Top collar to measure 1-3/8" at back, 3-1/2" at points. Opening of collar to measure 7/8". Collar
band to be loined with cotton pop; poplin stitched through y." apart. Collar stand to measure 1-112". Collar to be
fastened with one button. To have two pennanent type collar stays. Stitching for collar sty to be stitched so that
point of stay runs directly into center point of collar stitching.
YOKE - To be lined with same material as shirt.
SLEEVES - Long sleeves to be full cut and one piece. To be attached by a four-thread safety stitch. To have
banjo shaped elbow reinforcement and. one button and buttonhole on vent.
CUFFS - To have two buttons and matching buttonholes.
BADGE REINFORCEMENT - There shall be stitched reinforced badge support on left side above pocket
supported at yoke and pocked. To have two stitched eyelets 1-1/4" apart (center to center) and 1-1/4" above left
pocket.
SHOULDER STRAPS - Shoulder straps shall measure 2" at sleeve head and tapered to 1-5/8" at ends. Military
style cross-stitched (X) with button at neck. Buttons to be a tacked to yoke. To be made from 8-8-1/2 ounce
wool cloth.
POCKETS - To be 5" wide and 5-1/2" deep. Bottom comers to be metered and to have 1-112" box pleat in
center, stitched at top and bottom to prevent SPreading apart. Pencil division of 1" in left pocket. Center points to
be 2-1/2" long. Pocket flaps to be black.
POCKET FLAPS - To be 5-1/4" wide and scalloped, end points to be 2-1/4" long and to have velcro closures (to
be lined up with velcro on pockets and to be box-stitched). Center point to be 2-1/2" long with a pearlized black
button sewn on flap. To be full lined.
MILITARY CREASE - There shall be two Landtrex creases on front and three on the back.
CENTER PLACKET - Left front to have a placket extending from the collar to the tail. It shall be 1-112" wide
and there shall be two rows of stitching ~" fonn edges. Placket to have seven buttonholes (seven-button front
style) .
INSIGNIAS - Each shirt shall have shoulder emblems of the Richmond County Sheriff's Office, one on each
sleeve. Centered under shoulder strap and lOCated Yz" fro,.m sle~vehead. .. ~ ,.A ','
~~&aJu~~ (/-3