HomeMy WebLinkAboutBid_specs14
ITEM #1.
WINTER SIDRTS
SHIRT - WINTERlLONG SLEEVE:
SCOPE - The shirt shall be made in accordance with the following or comparable details unless otherwise
indicated. '
MATERIAL - Cloth shall be light grey 8...8...1/2 OZ., 55% Dacron and 45% Wool Tropical Worsted. All cloth
must be thoroughly cold water shrunk by the vendor before being used in any 'garment. Shall be Hamberger Co.,
Style 600 - 8 or approval equal.
Cloth shall meet the following specifications:
60 inch wide cloth
Weight
Construction
Fiber Content
Wool Grade
Yam Count
-~
~.:.
8...8...1/2 ounce
60 ends per inch - 50 picks per inch
55% Dacron 45% Wool
Blend of 62-64
Not less than 1150's Dacron & Wool warp and filling.
COLLAR - Top collar to measure 1...3/8" at back, 3...1/2" at points. Opening of collar to measure 7/8". Collar
band to be loined with cotton pop; poplin stitched through~" apart. Collar stand to measure 1...1/2". Collar to be
fastened with one button. To have two pennanent type collar stays. Stitching for collar sty to be stitched so that
point of stay runs di~ctly into center point of collar stitching.
YOKE - To be lined with same material as shirt.
SLEEVES - Long sleeves to be full cut and one piece. To be attached by a four...thread safety stitch. To have
banjo shaped elbow reinforcement and one button and buttonhole on vent.
CUFFS - To have two buttons and matching buttonholes.
BADGE REINFORCEMENT - lhere shall be stitched reinforced badge support on left side above pocket
supported at yoke and pocked. To have two stitched eyelets 1-1/4" apart (center to center) and 1-1/4" above left
pocket.
SHOULDER STRAPS - Shoulder straps shall measure 2" at sleeve head and tapered to 1...5/8" atends. Military
style cross-stitched (X) with button at neck. Buttons to be a tacked to yoke. To be made from 8...8...1/2 ounce
wool cloth.
POCKETS - To be 5" wide and 5-1/2" deep. Bottom comers to be metered and to have 1...1/2" box pleat in
center, stitched at top and bottom to prevent spreading apart. Pencil division of 1" in left pocket. Center points to
be 2-1/2" long. Pocket flaps to be black.
POCKET FLAPS - To be 5-1/4" wide and scalloped, end points to be 2-1/4" long and to have velcro closures (to
be lined up with velcro on pockets and to be box-stitched). Center point to be 2-1/2" long with a pearlized black
button sewn on flap. To be full lined.
MILITARY CREASE - There shall be two sewn in military creases on front and three on the back.
CENTER PLACKET - Left front to have a placket extending from the collar to the tail. It shall be 1-1/2" wide
and there shall be two rows of stitching ~" fonn edges. Placket to have seven buttonholes (seven-button front
style).
INSIGNIAS - Each shirt shall have shoulder emblems of the Richmond County Sheriff's Office, one on each
sleeve. Centered under shoulder straQ and located W' from sleeve head. hAJL.L ^ I
~~ {J---2J IV -J4{.